Dissertation > Excellent graduate degree dissertation topics show

Synthesis, Structure and Properties of PBO/SWNT Composite Fibres

Author: HuNa
Tutor: HuangYuDong
School: Harbin Institute of Technology
Course: Polymer Chemistry and Physics
Keywords: PBO/SWNT composite fibers PBO SWNTs structure properties of fibers
CLC: TQ340.64
Type: Master's thesis
Year: 2008
Downloads: 92
Quote: 0
Read: Download Dissertation

Abstract


PBO [poly (p-phenylene-2,6-benzobisoxazole)] fibre is a high performance fibres. It possesses super strength, super modulus and high thermal stability. It is a rigid-rod polymer and the molecular interaction is poor. This leads to fibres’defects such as the lower compressive strength and the inferiors ultraviolet radiation resistant ability. Because of these defects, PBO/SWNT composite fibres were prepared to enhance the mechanical properties and thermal stability and to improve its ultraviolet radiation resistant ability.Raw single-walled carbon nanotubes were treated with strong acid to increase the polarity functional groups on the surface of SWNTs. The products were named as SWNTs-COOH. The structure and the surface topograph of SWNTs were characterized. The results showed that the carboxyl groups were assuredly embodied on the surface of SWNTs after functionalization, which improved the solution ability in solvents.As the method was put forward, DADHB/TAP/SWNTs-COOH complex salt polymerized to PBO/SWNT composites. The synthesis of PBO/SWNT was studied and some crucial factors influencing polymerization were analyzed. The structure of PBO/SWNT composites and the DADHB/TAP/SWNTs-COOH complex salt were characterized. In addition, the single point method was employed to survey the special viscosity coefficient of PBO/SWNT composites. The results indicated that the way of SWNTs’addition and the amount of SWNTs’addition had important influences on preparing the PBO/SWNT composites.PBO/SWNT composites were spun by dry-jet spinning. The surface structure and the crystal structure of PBO/SWNT composite fibres were characterized. The thermal stability, mechanical properties and resistant ultraviolet radiation properties were analyzed. The results indicated that the surface of PBO/SWNT composite fibres was not as good as PBO fibres. The thermal stability of PBO/SWNT composite fibres was better than PBO fibres. In addition, the mechanical properities were promoted largely because of the synergy between SWNTs and PBO. When the amount of addition was 7.5mass%, the tensile strength of PBO/SWNT composite fibres was raised by 60%. At the same time, PBO/SWNT composite fibres improved its ultraviolet radiation resistant ability and expanded its application.

Related Dissertations

  1. Hydrothermal Synthesis of Oxide Hollow Spheres,TB383.4
  2. Research on the Mainframe System of Powder Mixed EDM and the Craft Experiment,TG661
  3. Investigations of Structure and Glass Forming Abilty of Amorphous Alloys,TG139.8
  4. Technology of Filling Clearance and Optimizing the Bonds during Ultrasonic Brazing,TG454
  5. Research on the Structure and Characteristics of Permanent Magnetic Coupling,TH139
  6. Finite Element Analysis and Structure Optimal Design for Combined Seal at Normal Temperature and Low Temperature,TH136
  7. The Study on Structural Calculation and Analysis Method of Lattice-type Crane with Variable Cross-section Boom,TH21
  8. Based on Nonliner Finite Element Analysis of the Infilled Wall Frame Structure,TU323.5
  9. Influence of over Fired Air on Gas-Solid Flows in a W-Shaped Flame Boiler,TK229
  10. Simulation Research on Compound-Structure Permanent-Magnet Synchronous Machine System Used in Hybrid Electric Vehicles,TM341
  11. Hong'an dialect syntax research,H146
  12. Adjust the structure of higher education in Yunnan Strategy Study,G649.2
  13. Research on Stability of Hierarchical Sattellite Network,TN927.23
  14. Research on Autamatic Music Structrue Analysis,TN912.3
  15. Research on Structure Transition Technology for SMT,TP391.2
  16. Research on Attitude Control Law of Endo-Atmospheric Missile,TJ765.23
  17. Study on Nonlinear Variable Structure Guidance Law,TJ765
  18. Sliding Mode Variable Tructure Control for Separating-Mirror System and Inhibit Chattering,TP273
  19. Modeling Analysis and Slip Estimation for Lunar Rovers,TP242
  20. The Relation between Fuzzy Logic Guidance Law and Homing Quality,TJ765

CLC: > Industrial Technology > Chemical Industry > The chemical fiber industry > General issues > Production process > Spinning
© 2012 www.DissertationTopic.Net  Mobile