Dissertation > Excellent graduate degree dissertation topics show

Preparation and Research of P-N Junction Based on SnO2

Author: YangXiaoWei
Tutor: ZhangWeiFeng
School: Henan University
Course: Physical Electronics
Keywords: p-type SnO2:Al films SnO2based p-n junction Magretron sputtering Preparation andcharacterization NiO films
CLC: TN304.055
Type: Master's thesis
Year: 2013
Downloads: 1
Quote: 0
Read: Download Dissertation

Abstract


Transparent conducting oxides （TCOs） are widely used in a variety of applications such as frontsurface electrodes of solar cells and flat panel displays, low emissivity windows, touch-panel control,defrosting windows of aircraft, and static dissipation layer due to the characteristics of low resistivity andtransparency in the visible region. Research on the p-type transparent conductive oxide has graduallybecome one of the hot spots in recent years. However, most of the TCO films has been put into applicationand application are the n-type conductive film and p-type conductive film is seldom applied. As a moreappropriate candidate for p-type doped materials, SnO2is suitable for practical applications.1. The Al-doped SnO2transparent conductive thin films were deposited on the quartz glasssubstrates by magnetron sputtering using Al metal target and SnO2ceramic target. The best condition forsputtering p-type SnO2:Al thin films is that the substrate temperature is300℃. The sputtering time ofaluminum film is40s and incubated in470℃for4hours after the end of sputtering. In this experiment, thehighest hole concentration is5.854×1019(cm-3) with the lowest resistivity is2.878×10-2（Ω·cm） and hallmobility is2.721(cm2（V·sec）-1).2. SnO2: A1film has a tetragonal cassiterite structure, After annealing incubated for4h at atemperature of470℃, the average grain size of the film is13.16nm, smaller than before, grain density isincreased, The film surface becomes smooth and the surface roughness decreased. In addition, the averagetransmittance of films in visible region is high as80%.3. Sb-doped SnO2transparent conductive thin films were deposited on quartz glass substrates useby magnetron sputtering. It has a tetragonal cassiterite structure. SnO2: Sb film is very uniform, dense, smooth, constituted by columnar nano-particles, with better microstructure. After annealing incubated for4h at a temperature of550℃, it is observed that NiO films are highly crystalline in nature with preferredorientation along the （200）、（220） direction by using magnetron sputtering.4. p-n heterojunctions （p-NiO/n-SnO2:Sb）and homojunctions（p-SnO2:Al/n-SnO2:Sb） wereassembled using the above prepared p-SnO2/n-SnO2and p-NiO thin films. They are highly crystalline innature and with better microstructure. The current-voltage （I-V） characteristics of homojunctions（p-SnO2:Al/n-SnO2:Sb） show the rectifying characteristics of typical p-n junctions. The open-circuitvoltage is3.77V. The average transmittance of films in visible region is72.4%. Lattice matching degree ofheterojunctions （p-NiO/n-SnO2:Sb） is12.9%. The I-V curve of the heterojunction is nonlinear, showingvery good rectifying and the open circuit voltage of3.5V. The average transmittance of the heterojunctionin the visible range is81%.

Related Dissertations

  1. Electrodeposition and Properties of Co-doped Nicke Oxide Electrochromic Thin Film,TB383.2
  2. The Preparation and Property Studies of NiO, TiO2 and ZnO Films by Magnetron Sputtering,O484.1
  3. Preparation and Characterization of Ultra-fine Iron Powder and Boron Powder,O613.81
  4. Preparation and Physical Properties of Mn and Co-doped SiC Diluted Magnetic Semiconductor Films,TN304.055
  5. Design and Analyze of MOCVD System Reactor,TN304.055
  6. The MOCVD Growth Research on AlGaN Epitaxial Layer with High-Al Concentration,TN304.055
  7. a-Si: H thin film preparation and characterization of MWECR CVD,TN304.055
  8. Research on Technology of Gas Delivery System in Multi-chamber Metal Organic Chemical Vapor Deposition Equipment,TN304.055
  9. Research and Discussion segregation characteristic P-type impurity in SiO_2-Si within the Ga interface,TN304.055
  10. MOCVD growth and characterization of the lateral epitaxial GaN materials,TN304.055
  11. Growing LiNbO3 Film on Silicon Substrate by Pulsed Laser Deposition,TN304.055
  12. The Preparation of Gallium Nitride Thin Films on Substrate Silicon and Investigation of GaN based UV-Detectors,TN304.055
  13. Preparation of Poly-silicon Thin Film in Low Temperature Using SiCl4 as Gas Source by PECVD,TN304.055
  14. Dynamics of EACVD in H2/C2H2,TN304.055
  15. Deposition of Nanograin Polycrystalline Silicon Thin Films and Its Structural Characterization by Hot-Wall LPCVD,TN304.055
  16. Study on the Growth of Carbon Nitride Filims by PE-CVD and the Related Gas-phase Reaction,TN304.055
  17. Synthesis of Nano-diamond Films by CVD Technique at Low Temperature and its Nechanism Study,TN304.055
  18. ECR_PAMOCVD epitaxial growth of plasma micro C_GaN process parameters on the influence of substrate pretreatment,TN304.055
  19. The application of control technology in the growth process of GaN films,TN304.055
  20. The CH4/H2 System electron assisted hot filament chemical vapor deposition kinetics of the process of research,TN304.055
  21. Research and Design of the Third Generation of MOCVD Control System Based on PLC,TN304.055
  22. PLC-based control system optimization design MOCVD,TN304.055

CLC: > Industrial Technology > Radio electronics, telecommunications technology > Semiconductor technology > General issues > Material > General issues > > Semiconductor thin film technology
© 2012 www.DissertationTopic.Net  Mobile