Dissertation > Excellent graduate degree dissertation topics show

Study on Signal Processing Method of a Laser Synthetic-wavelength Nanomeasurement Interferometer

Author: ZhangPing
Tutor: ChenBenYong
School: Zhejiang University of Technology
Course: Measuring Technology and Instruments
Keywords: Laser interferometer Synthetic wavelength CPLD Nanometer measurement Signal processing
CLC: TN249
Type: Master's thesis
Year: 2010
Downloads: 83
Quote: 0
Read: Download Dissertation

Abstract


In recent years, with the micro-electronics, ultra-precision machining and other high-tech rapidly developing, nano-displacement measurement techniques and instruments for large displacement measurement with nanometer accuracy are demanded. This thesis is supported by“The development of a laser synthetic-wavelength nanodisplacement measurement interferometer”(NSFC, No.50827501). A signal processing system of the interferometer based on a complex programmable logic device (CPLD) is designed and developed.Based on the principle of fringe subdivision by using a synthetic wavelength, the method of interferometric signal processing of the interferometer is researched. A novel nanomeasurement method is proposed to compensate the counting errors which usually occur at the oscillation or at the ending position of interferometric fringe during measurment. A hardware system for the signal processing method is designed in detail and realized, including CPLD processing modules, a signal pre-processing circuit, a power circuit, a clock circuit, a JTAG debug circuit and a serial communication circuit. And the software system for the signal processing method is analyzed and designed, which is programmed by using Visual Basic language.In this research work, experiments are done as below:(1) Fractional fringe counting experiment: displacement measurement experiments with 5nm, 10nm and 20nm deplacement increments were carried out, respectively. The experimental results show that the linear correlation coefficient is 0.9991, 0.9998 and 0.9998 with the standard deviations of 1.85nm, 2.54nm and 2.20nm over a range of 200 nm, respectively.(2) Integral fringe counting experiment: In the measuring range of 15μm, the maximum deviation is 0.303μm less than half a wavelength.(3) Combination of integral and fractional fringes counting experiment: displacement measurements with 0.5μm and 1μm deplacement increments were carried out, respectively. In the measuring range of 15μm, the standard deviation is 5.75nm and 8.51nm, respectively. The experiment results show that the designed signal processing system can acheive both large displacement measurement and nanometer measurement accuracy and it has high reliability and practicability.

Related Dissertations

  1. Research on the Image Acquisition System Based on CMOS Star Sensor,V448.2
  2. Research on Synchronous Motor Excitation Control System,TM341
  3. Research on the Optimization of Laser Triangulation Device,TH744.5
  4. Study of Data Generation for MMW Radar IF Simulated Signal Source,TN955
  5. Design the Control System of Ocean Wave’s Simulation Table Based on Theory of Fuzzy Turning PID,TP273.4
  6. Design of Testing Equipment for Electronic Products,TN06
  7. Design and Implementation of Processor TI DSP VC33 Virtual Kernel,TP332
  8. Design of Receiving Processor on Radio Signal and Multi-Rate,TN851
  9. MATLAB for post-processing in the radar signal processor system simulation applications,TN957.51
  10. Application of AWG in Decoy Protection Equipment,TN97
  11. The Study on the Technology of Airborne Radar Anti-jamming,TN974
  12. Study on Alignment Method of a Laser Synthetic Wavelength Nanomeasurement Interferometer,TH744.3
  13. Design and Implementation of Cone-beam CT Control Card Based on PCI Bus,R318.6
  14. Research Implementation of Crack Detection Method Based on Its Acoustic Property,TP274
  15. Second-order Circulation Statistics-based Array Signal Processing,TN911.7
  16. Development of a multi- speed radar measurement system answering machine,V556
  17. Design and Implementation of Interface Board for 340MHz Wireless Transceiver,TN859
  18. Study on a Portable Measurement and Analysis Instrument for Ships Shafting,U664.21
  19. Research on Signal Processing Unit of Optical Voltage Transformer,TM451.6
  20. Research and Design of Rf Modules Console Based on CPLD,TP391.44
  21. Research and Design of Electronic Equalization Based on Most Likelihood Sequence Estimation,TN911.5

CLC: > Industrial Technology > Radio electronics, telecommunications technology > Photonics technology,laser technology > Laser technology, the maser > Laser applications
© 2012 www.DissertationTopic.Net  Mobile