Dissertation > Excellent graduate degree dissertation topics show

Study on Gas Phase Oxidation-Liquid Phase Absorption Process for Removal of NO_x from Industrial Waste Gases

Author: YuanCongHui
Tutor: ChenYinFei；LiuHuaYan
School: Zhejiang University of Technology
Course: Industrial Catalysis
Keywords: NO_x catalytic oxidation alkali solution absorption modified activated carbon
CLC: X701
Type: Master's thesis
Year: 2008
Downloads: 48
Quote: 0
Read: Download Dissertation

Abstract


Liquid absorption and NO catalytic oxidation were systematically investigated to remove NOx in the waste gases from the fine chemical,pharmaceutical and nitric acid industries. These waste gases were emited under room temperature and normal pressure and contained much oxygen and vapor,while the oxidation degree of the NOx was very low.The NOx removal efficiencies of the liquid absorption were studied in the NaOH solution and the NaOH solutions which contained oxidant or reducer.The influences of the relative humidity,the reaction temperature and the contact time on the NO oxidation behavior over the modified activated carbon（MAC）were also investigated. Some conclusions were drawn as follows:The NOx removal efficiency increased with the increasing of NOx oxidation degree in（NH4）2SO3-NaOH liquid and H2O2-NaOH solution,while there was an optimal oxidation degree 50-60%for the NaOH solution and urea-NaOH absorption liquid,thus the optimum oxidation degree for the solution removal efficiency was different from each other.The removal efficiency of NOx increased with the NOx concentration increase, and the contact time was favorable for the NO2 removal when contact time rose.During the NO catalytic oxidation over the MAC,the NO conversion increased with the reaction time,while it was severely inhibited by the water vapor content.The maximum NO conversion was obtained at 50-70℃in humid gas,while decreased with the temperature increase in the dry gas.Under the conditions of the saturated water vapor at 20℃,NO concentration 650 ppmv,contact time 4 s,and temperature 50℃, the NO conversion was gotten to be 51%.By the above investigation,two new multi-stage processes were proposed for the NOx removal of the industry waste gas. One is for the nitric acid industry,which was made up of the catalytic oxidation-caustic alkali absorption,and another for the fine chemical and pharmaceutical industries,which contained catalytic oxidation-ammonium sulfite alkali absorption.The processes could decrease the NOx content to be lower than 100 ppmv and 120 ppmv respectively.

Related Dissertations

  1. Experimental Research on Influence of Coal Reburning Reaction Conditions on NO_x Reduction by Non-Catalytic Reduction of Ammonia,X701
  2. The Effect of Composite Additive on the SNCR,X701
  3. Study of Method and Facilities for Transfering from Hot Air to Exhaust Air Converying System,TK223.25
  4. Numerical Simulation on Pulverized Coal Combustion Process in a 670T/H Tangential Firing Furnace,TK224.11
  5. Under microaerobic conditions closed calcium carbide furnace exhaust COS gas adsorption purification,X781
  6. The Study of NO Low-temperature Catalytic Oxidation Over MnFeO_x Catalyst,X701
  7. Study on Durability and Poisoning Resistant Performance of Pt/C and Pt/OMC Catalysts,O643.36
  8. Study on Electrochemistry and Raman Spectrum of Picoline Electro-Oxidation Beavior in Non-aqueous System,O626.321
  9. Heterogeneous Fenton Reagent Preparation and applied research in the treatment of coking wastewater,X703
  10. Catalytic Oxidation of NO at Room Temperature by Activated Carbon Fibers and Modified Activated Carbon Fibers.,X511
  11. Study on the Measurement and Calculation of Emission from Marine Diesel Engine,U664.121
  12. Numerical Simulation of the Combustion Process and NO_x Emission of Homogeneous Charge Compression Ignition Marine Diesel Engines,U664.121
  13. Analysis on Economy and Emission Change of Navigation at Reduced Speed,U692
  14. Metal porphyrin β- structural modification of the catalytic air oxidation of cyclohexane,O643.32
  15. Catalytic Oxidation of Alicyclic Alkene with Polyoxometalates,O643.32
  16. Experimental study of the dye wastewater treatment process,X788
  17. Research on Desulphurization by FeSO4 Aqueous Catalytic Oxidation and by Using the Serosity of White Sludge or Salt Sludge of Ammonia Alkali Mills,X793
  18. Flow Model Test and CFD Numerical Calculation Study for Flue Gas SCR Reactor of Coal-Fired Power Plant,X701.3
  19. Raw material coke the adsorption simulation the flue gas SO_2/NO characteristics experimental study,TK6
  20. Non-thermal Plasma Assisted Catalytic Oxidation on Manganese-based Catalysts for Nitrogen Oxides Abatement,X511

CLC: > Environmental science, safety science > Processing and comprehensive utilization of waste > General issues > Exhaust gas processing and utilization
© 2012 www.DissertationTopic.Net  Mobile