Dissertation > Excellent graduate degree dissertation topics show

Experiment Study on Ilmenite Disposal by Directing Reduced Process

Author: ZhangRui
Tutor: ZhangChaoZuo
School: Xi'an University of Architecture and Technology
Course: Iron and steel metallurgy
Keywords: Vanadiferous titanomagnetite ilmenite direct reduction solid-state reduction
CLC: TF55
Type: Master's thesis
Year: 2009
Downloads: 375
Quote: 3
Read: Download Dissertation

Abstract


Vanadiferous titanomagnetite ore is quite rich in An-Kang Zone(Gaoqiao Town of Ziyang County and Guanyuan Town of Langao County in Shaanxi Province) of China and its explored reserve is up to 0.472 billion tons,whose associated titanium dioxide mineral reserve is also up to 26.855 million tons.However,the mineral belongs to typical poor thin miscellaneous complex ore,whose content is low grade, component is very complex,and accumulation is hard too.Therefore,the separation of Ti-Fe andcomprehensive utilization is very hard.For the sake of conquering disadvantage of refining iron by blast furnace and reclaiming titanium effectively,the direct reduced iron(DR/) method is adopted in this paper.The DRI method can reduce iron ore which is in solid state condition to iron directly.Because the component of DRI is stable and the content of harmful element is low,especially inclusion element of anti-oxidation metal is little,so it can be used as pure material for smelting high quality steel or special steel,meanwhile,it can also be Used for foundry, ferroalloy,and powder metallurgy and so on.In view of the vanadiferous titanomagnetite concentrate and ilmenite concentrate being obtained by vanadiferous titanomagnetite ore separation,solid-state reduction behavior of ilmenite and fundamentals of strengthening reduction processes are discussed deeply by these theories of thermodynamics,kinetics,mechanochemistry, and so on.Based on the above investigations,a new technology process for comprehensive utilization of vanadiumferous titanomagnetite by solid-state reduction method is developed.The following conclusions are obtained.The thermodynamics shows that the temperature for reduction reaction of ilmenite should be controlled less than 1100℃;The reduction kinetics shows that reduction rate of ilmenite is slow and reduction can not reach high reduction level;Investigation on effect of additive on preoxidation reduction behavior of ilmenite shows that the homemade sodium metal-salt additive can influence solid-state reduction behavior of ilmenite observably.Finally,the test results for factory are obtained as following,the mass ratio of coal and breeze after machining is 14:100,the reduction temperature is 1150℃,and reduction time is 180min.When the activator content is 3%,the iron concentrate whose titanium content is less than 8%and iron content is up to 76.56%can be obtained by coal-based reduction technology.The analysis result indicates that direct reduction technology for vanadiferous ilmenite is a technology for comprehensive utilization of resources,which pioneers a feasibility technology route for comprehensive utilization of vanadiferous titanomagnetite in China.

Related Dissertations

  1. Study lithium titanate prepared from ilmenite,TM912
  2. Panzhihua ilmenite preparation of high -grade titanium-rich material of the new technology research,TF823
  3. Study on the Temperature Rising Behavior and Coal-based Direct Reduction of Iron Oxides in Microwave Field,TF046.6
  4. Hydroxamic acids collector properties and synthesis of research on ilmenite flotation,TD923.13
  5. Experimental study on microwave-assisted ground Panzhihua ilmenite,TD921.4
  6. Panzhihua Iron and iron- sulfur sulfur reduction of iron ore to mention Study,TD951
  7. Oxygen top blowing smelting ilmenite smelting reduction technologies Experimental Study,TF557
  8. To improve Kunming sand perovskite mineral recovery research,TD952
  9. A Basic Research on Preparation of Ti-rich Material Process Intensification by Reduction Corrosion Method from Ilmenite,TF823
  10. Production of raw materials of large DC arc furnace smelting titanium slag,TF823
  11. Response surface methodology to optimize the extraction process ilmenite,TD926.4
  12. The Study on Polyaniline and Nickel Oxides as Electrode Materials of Supercapacitor,TM53
  13. Investigation on Ilmenite Reduction Strengthening Technology and Mechanism,TF041
  14. Study on New Mineral Processing Technology of Refractory Ilmenite,TD92
  15. The structure and nature of variation of mechanically activated Panzhihua ilmenite concentrate minerals,P573
  16. Study on Strengthen Coal-based Direct Reduction of Iron Ore Pellets by Microwave Heating,TF554
  17. Basic Research on Refining of High Titanium Ferroalloy Based on Thermite Reduction,TF64
  18. Reaction and Separation Process Research on Clean Metallurgical Technology of Titanium Dioxide with Alkaline,TQ621.12
  19. Novel Process and Mechanisms of Preparing Ferronickel Materials from Nickeliferous Laterite Ores,TF644
  20. Study on Coal-based Direct Reduction of Pre-reduction Pellet Heated by Microwave,TF55
  21. Influence of Surface Dissolution on the Flotability of Ilmenite and Titanaugite,TD91

CLC: > Industrial Technology > Metallurgical Industry > Ironmaking > Iron ore directly restore
© 2012 www.DissertationTopic.Net  Mobile