Dissertation > Excellent graduate degree dissertation topics show

Testing and Optimization on Cold Aerodynamic Field of 600MW Subcritical Boiler

Author: WangZuo
Tutor: RanJingZuo；ZhaoHuaBang
School: Chongqing University
Course: Power Engineering
Keywords: 600MW subcritical unit opposite firing aerodynamic field in the furnace cold state experiment
CLC: TK223.23
Type: Master's thesis
Year: 2008
Downloads: 140
Quote: 0
Read: Download Dissertation

Abstract


Dong-fang Boiler Group Ltd Co designs and manufactures a new type improving boiler for Pan-nan power plant unit 1 using the technology of British Mitsui Babcock company,it is the first 600 MW subcritical boiler that has been put into use in Southwest of China.This type boiler is unit opposite firing boiler with natural circulation steam drum stove and LNASB(Low NOx Axial Swirl Burner) axial cyclone pulverized coal burner.Because of lack of functioning experience,these problems require our more attention in the process of functioning,such as the practical work,the distribution of aerodynamic field.Therefore the experiment and optimization of cold state aerodynamic field in the furnace for 600MW subcritical boiler is significance and value in project.This paper is in view of the type 600MW subcritical boiler with unit opposite firing, through deeply to analysis the cold state experimental conditions of boiler,experimental methods and on base of the principle of data processing and calculation.The test point and the arrangement were determined.The relations between the secondary air speed and amount of the secondary air nozzle,the relations between the secondary air eddy intensity and cyclone’s position,and leveling the primary air in the same layer were also researched by experiment.According to the experimental results,the aerodynamic field distribution of this boiler was further analyzed and the optimization improvement plan was proposed.The results show that the determined boiler unit experimental condition and experimental method is feasible and reasonable,the calculation principle and method for data processing and correction are correct,the measuring point and the arrangement are reasonable.Experimental study indicates the furnace has a certain fullness under different air match ways,the adjacent and layer burner jet without mutual interference; Side wall air current speed is low and hasn’t obvious washout phenomenon,the burner jet hasn’t formed the phenomenon of full-proliferation jet washout furnace wall and adherent the wall;the OFA primary burnout air has a big jet rigidity and a slow proliferation decay,and also it has a strong penetration capability.Through calibration for BS-1 measuring speed tube of 1# boiler cold state primary air,it shows the flow coefficient is stable and can be used in the experiment for the primary air adjustment measurement and the leveling of the primary air in the same layer.The secondary air sleeve of 1# boiler burner has an obvious regulation impact to the air speed with its opening of 0%-50%,they assume the linear relation ship basically; when the opening of the secondary air sleeve above 50%,it almost hasn’t any effect on the change of speed.After optimization,the initial location of the cyclone and throttle burner sleeve should be in Table 5.9 to set up to organize combustion.

Related Dissertations

  1. Depolymerization of Polybutylene Terephthalate in Subcritical Aqueous Acid Solution and Sub/superctitical Ethanol,O631.3
  2. Study on Fluidization and Drying of the Group C Particles in a CFB System,TQ028.67
  3. Experimental study on Jatropha biodiesel,TE667
  4. Thermal Economic Performance Analysis and System Optimization of 600MW Power Unit,TM621.4
  5. A Study on Selective Oxidation of Cellulose, Lignin and Lignite in Subcritical Water,TQ351.0;TQ531
  6. Numerical Simulation and Experimental Research of Shutter Separator Used in Down-Fired Boiler,TK229
  7. Study on the Strength and Toughness of 35CrMoA Steel by Intercritical Hardening,TG156.3
  8. Study on Supercritical/Subcritical Water Oxidation of p-Nitrophenol Wastewater,X703
  9. Study on Extraction of Essential Oils from Kaempferia Galangal L. by Ultrasound-enhanced Subcritical Water,TQ461
  10. The Preparation and Kinetic Study of Biodiesel from Jatropha Oil Under Subcritical Condition,TE667
  11. Design and Implementation of Correspond Control System for 600MW Supercritical Unit,TM621.6
  12. The Research of Surface Movement Law on the Stepwise Mining Deep,TD325
  13. Influence Factors of Polycarbonate Depolymerization in Sub-Critical Water,TQ323.4
  14. Subcritical water of poly (butylene terephthalate) ( catalytic ) depolymerization of,O631.3
  15. Numerical Study of Gas-solid Hydrodynamic Characteristics in a 600MW Supercritical CFB Boiler,TK229.6
  16. The Existence of Multiple Solutions for Semilinear Schr(?)dinger Equation Without Ambrosetti-Rabinowitz Condition,O175.2
  17. Study on the Low Temperature Properties of Subcritically Quenched 40CrNi2Mo Steel,TG161
  18. Existence and Multiplicity of Solutions for Elliptic Equations with Hardy Terms and Critical Weighted Hardy-Sobolev Exponents,O175.25
  19. Vibration Analysis of Domestic 600MW Super-crititial Steam Turbo-set,TM621.2
  20. The Existence of Nontrivial Solution to a Nonlinear Elliptic Boundary Value Problem of p-Laplacian Type without Ambrosetti-Rabinowitz Condition,O175.8
  21. Stability of Pc Depolymerization Products in Super/Sub-Critical Methanol and Methanol/Water Co-Solvent System,X705

CLC: > Industrial Technology > Energy and Power Engineering > Steam Power Engineering > Steam boiler > Boiler constructed > Combustion devices > Burner
© 2012 www.DissertationTopic.Net  Mobile