Dissertation > Excellent graduate degree dissertation topics show

Study on Acid Hydrolysis of Rice Straw and Biotransformation Manufacturing Fuel Ethanol

Author: LiHui
Tutor: GuoJianPing；YinZuoLin
School: Hunan Normal University
Course: Applied Chemistry
Keywords: rice straw acid hydrolysis detoxification fermentation fuel ethanol progress conditions
CLC: TQ223.122
Type: Master's thesis
Year: 2009
Downloads: 314
Quote: 6
Read: Download Dissertation

Abstract


With the aggravation of energy crisis,the development and utilization of biomass has become the research hot spots.Rice straw is an important biomass,with wide distribution and enormous amount.It was incinerated uausally,resulting in serious waste of resources and environmental pollution.Due to its high content of lignin,which would easily produce inhibitors to fermentation after treatment,the research work of rice straw has just started.Comprehensive development of biomass energy has strategic significance.The experiments of hydrolysis of rice straw catalysed by dilute sulfuric acid were conducted.The influences of concentration of acid, reaction temperature and reaction time on hydrolysis of rice straw producing reducing sugar were discussed in this thesis.The results showed that hydrolysis of rice straw using dilute sulfuric acid can leave out the progress of pretreatment,with good yield of reducing sugar.The optimum reaction conditions of hydrolysis of rice straw by dilute sulfuric acid were as follows:dilute sulfuric acid mass fraction 20%,reaction temperature 60℃,reaction time 36 h,and the largest yield of reducing sugar can reach 30.41%under these conditions.When the ratio of solid to liquid(W/V) was 1:10,the concentration of reducing sugar can reach 23.835 g/L. Hydrochloric acid and mixed acid contrast test showed that the mixed acid had the highest efficiency to hydrolysis of rice straw,and could significantly shorten the reaction time.For the total progress of hydrolysis of rice straw,we considered that the hydrolysis of hemicellulose was taken at the first 4 hours,and cellulose at 16 hours to 36 hours,the whole progress finished after 36 hours.The detoxification of the obtained acid-hydrolysis solution was studied,and the existing detoxification methods were improved.The rice straw acid-hydrolysis solution was excessive neutralized using calcium hydroxide while pH reached 8-9,accurately regulating to 7.0 using phosphoric acid.Then 3%of volume rate of add activated carbon were added in,after stirring for 30-40 minutes at 60℃,filtered,and concentrated on vacuum.The influence factors of fermentation of rice straw acid-hydrolysis solution after detoxification to produce ethanol were discussed in this thesis,such as concentration of reducing sugar,pH,and concentration of ethanol.The optimum conditions of fermentation were as follows:the concentration of initial sugar was 75 g/L,the inoculation quantity was 8%, the fermentation temperature was 34℃,reaction time was 84 h,and the concentration of ethanol could reach 4.362 g/L under the above conditions. Comparing the fermentation of rice straw acid-hydrolysis solution and glucose,the result showed that the rice straw acid-hydrolysis solution had low utilization ratio of reducing sugar,less decline of pH,and deficiency of posterior ability of fermentation.The possible reasons were that there were less fermentable sugars in rice straw acid-hydrolysis solution and the detoxification of it was incomplete.

Related Dissertations

  1. Haihong Fruit Vinegar Processing Technology,TS264.22
  2. The Clinical Observation of the Lupus Detoxification Pill on Treating the Remission of Systemic Lupus Erythematosus,R259
  3. Studies on Fermentation Optimization, Purification and Enzyme Characteristics of Lipase from Aspergillus Oryzae FS-1,TQ925.6
  4. Optimization of Fermentation Conditions, Purification, Cloning and Expression of a Cold-active Lipase from Pseudomonas Sp.RT-1,TQ925
  5. Research on Anaerobic Fermentation Processing Technology of Dead Tilapia,TS254.4
  6. Assessment of Resistance Risk in Spodoptera Exigua (Hubner) and Spodoptera Litura (Lepidoptera: Noctuidae) to Chlorantraniliprole,S433
  7. Effects of 2-Hydroxy-4-Methionine Isopropyl on Rumen Fermentation and Production Performance of Holstein Cows,S823.8
  8. Study on the Breeding of High Efficient Detoxification Strains and Suggestion Parameters of Solid Fermentation on Cottonseed Meal,S816.6
  9. The Effectr of Lactic Acid Bacteria and Rice Bran on Dynamic Change of Rice Straw Silage Fermentation,S816.53
  10. Insecticidal Activities of Recombinant CryIAc Protein from Bacillus Thuringiensis and Solid Fermentation Products from Aspergillus Terreus PNR2,S476.1
  11. Yu Ren- Cun Academic Thought and clinical experience in the clinical observation of combination chemotherapy in advanced gastric cancer with Yiqihuoxuejiedu side,R249
  12. Effect of Celluases and Lactobacillus on Fermentation Quality of Bi-Crop Silage of Whole-Crop Corn and Common Vetch,S816.53
  13. Mutation Inducing Breeding of Avilamycins Production and Optimization of Fermentation Conditions,TQ927
  14. The Influence of Coumaphos on Enzyme Activities of Antheraea Pernyi and Blepharipa Tibialis Chao,S885.1
  15. The Mutation Screening and the Production Optimization of Avermectin Producing Strain,TQ450.6
  16. Identification and Robustness Analysis of Nonlinear Hybrid Dynamical System Concerning Glycerol Transport Mechanism,TQ223.162
  17. Studies on the Techniques of Multi-season Cultivation for Nanling Mushroom,S646.11
  18. Isolation and Purification of a Novel Antifungal Antibiotic and Optimization of Its Fermentation Conditions,TQ927
  19. Modeling and Simulation Software Design for the Glutamic Acid Fermentation,TQ922.1
  20. Scleroderma Polyrhizum Pers. Strains of Pharmacognostic and Breeding, Fermentation Technology Research,S646
  21. Titanium concentrates preparation of the new technology of the titanium - rich material,TF823

CLC: > Industrial Technology > Chemical Industry > Basic Organic Chemistry Industry > The production of aliphatic compounds ( acyclic compounds) > Aliphatic alcohols (alcohols, hydroxy compounds) and its derivatives > Aliphatic alcohol > Fatty Alcohols > Ethanol ( alcohol )
© 2012 www.DissertationTopic.Net  Mobile